摘 要：植桑養蠶是我國一些地區的傳統產業，在養蠶過程年產近百萬噸的蠶沙。為了合理利用蠶沙資源，本課題主要研究了制備葉綠素銅鈉鹽的新工藝，并優化了工藝條件，以指導工業生產。首先對原料蠶沙進行葉綠素提取率的測定，并將微波提取法與普通溶劑提取法進行比較。結論證明，微波提取法的提取率要比普通溶劑提取法的提取率高出一倍。其次考察了預處理過程中微波輻射時間、溶劑用量、溶劑與物料比例等因素的影響，確定初步的蠶沙萃取工藝條件，并優化相關的工藝條件。在試驗范圍內所得的數據表明:在微波輻射時間90s、破壁劑濃度40%、破壁助劑用量1：2(V[ml]:W[g]) 、提取溫度60min的條件下，提取效果最佳。最后，研究了所提取的葉綠素溶液皂化條件，并摸索了葉綠素銅鈉鹽的制取條件。發現分離操作中，溫度40℃、皂化60min效果明顯，在酸性pH值為2.4的條件下銅代的60min效果較好，得到的產品品質也好。
關鍵詞:蠶沙；微波輔助萃取;金屬卟啉




Research on porphyrin-Copper-Sodium separate from silkworm

Student’ s name: DU qiang­wei Advisor: WANG Shi­cai
（School of Biological and Chemical Engineering Zhejiang University of Science and Technology）

Abstract: For rationally utilizing silkworm faeces，it was primarily researched in this article on the new processing of preparing sodium copper chlorophyllin from silk worm and the optimal processing faeces to coaching industry production. Firstly,some work has been done on the chlorophyll extraction rate from silkworm with two different method.The conclusion proves that the extraction rate of microwave assistant extacrtion is two times than the conventional one.In this study，the influence factors were studied including irradiated time，volume of solvent，co-agent proportion etc. during the microwave pretreatment procedure.And by these investigations，tussah extracted condition was determined and optimiezd. The results indicated best that under the following conditions:irradiaetd time 90s，the concentration of cell wall crack agent 40%，the ratio of material and cell wall crack agent is 1：2(V[ml]:W[g])，extracted temperature 60℃.Lastly，the operating conditions were found for chlorophyll solvent separation and chlorophyllin-copper-sodium preparation. The excellent Saponification effect can be obtained under the following parameters:tempeartuer 40 saponated time 60min; Under the acidity condition，the yieldis higher after 60 min copper exchanged reaction.
Keywords：silkworm；microwave assistant extraction; metalloporphyrin









目 錄
中文摘要 I
英文摘要 II
目錄 III
1 緒論 1
1.1 蠶沙簡介 1
1.1.1蠶沙的主要成分 1
1.1.2蠶沙的應用概況 1
1.2卟啉及金屬卟啉簡介 2
1.2.1結構及性質分析 2
1.2.2 卟啉及金屬卟啉化合物的合成 3
1.2.3應用概況 5
1.3課題研究意義 7
2 試驗部分 8
2.1試驗所需藥品和儀器列表 8
2.1.1主要化學藥品 8
2.1.2主要試驗儀器 8
2.2實驗原理及工藝流程圖 8
2.2.1實驗原理 8
2.2.2工藝流程圖 9
2.3蠶沙中葉綠素提取工藝條件 10
2.3.1單因素試驗 10
2.3.2 正交試驗 11
2.4葉綠素制取卟啉銅鈉鹽的實驗 12
2.4.1皂化試驗 12
2.4.2 銅代試驗 12
2.5 分析檢測方法 13
2.5.1分光光度法測量葉綠素含量 13
2.5.2卟啉銅鈉鹽的測定 13
3 結果與討論 14
3.1蠶沙中葉綠素含量測定結果 14
3.2微波提取法與溶劑提取法的對比試驗 14
3.3蠶沙中葉綠素提取試驗 15
3.3.1單因素試驗結果 15
3.3.2正交試驗 19
3.4葉綠素制取卟啉銅鈉鹽的試驗 20
3.4.1皂化試驗結果分析 20
3.4.2銅代試驗結果分析 22
3.4.3卟啉銅鈉鹽的檢測結果 23
4 總結與展望 26
致 謝 27
參考文獻 28